Caterpillar-3512-Diesel-Generator-Set-1012
New listingFeatured
On Call

Caterpillar 3512 Genset 1250KW

The Caterpillar Power Package is housed in 40FT Enclosure. Equipped with heating system and lighting equipment.

  • Manufacture: Caterpillar
  • Model: 3512
  • Housed in a 40FT Enclosure
  • Standby Rating: 1250 kW
  • Continuous Duty: 1000 KW
  • Generator:  Caterpillar 2 Bearing SR4 Generator
  • Voltage: 4160/2400 volts
  • Genset Frequency: 60 HZ,
  • Hours: Only 7611 hours of operation since total rebuild by Finning Cat.
  • Has been serviced and maintained by Caterpillar Dealer.
  • Utility grade Synchronizing Switchgear
  • External Radiator,
  • This package is set up for Remote Operations.
  • Equipped with a heating system and lighting equipment for cold weather conditions.
  • Caterpillar 3512 Genset 1250KW in Very Good Condtion

GENERATOR SET SPECIFICATIONS

Maximum Rating1250 ekW
Minimum Rating890 ekW
Emissions/Fuel StrategyLow Fuel Consumption
Voltage380 to 13800 Volts
Frequency60 Hz
Speed1800 rpm
Duty CycleStandby, Mission Critical, Prime, Continuous

ENGINE SPECIFICATIONS

Engine Model3512 TA, V-12, 4-Stroke Water-Cooled Diesel
Bore6.69 in
Stroke7.48 in
Displacement3161.03 in³
Compression Ratio13.5:1
AspirationTA
Fuel SystemDirect Unit Injection
Governor TypeWoodward

3512 (60 HZ) STANDARD EQUIPMENT

AIR INLET SYSTEM

  • Air cleaner; single element canister type with service indicator

AIR INLET

  • Air Cleaner

COOLING

  • Radiator fan and fan drive
  • JWAC.

EXHAUST

  • Exhaust flange outlet
  • Dry Exhaust Manifold

FUEL

  • Secondary fuel filter
  • Primary fuel filter with integral water separator
  • Fuel cooler; not included with packages without radiator
  • Secondary fuel filters
  • Fuel priming pump

GENERATOR

  • IP23 Protection
  • Matched to the performance and output characteristics of Cat engines

POWER TERMINATION

  • Bus Bar

CONTROL PANEL

  • Accessory module data link
  • Features include:
  • Over / under voltage (27 / 59)
  • Coolant temperature
  • Generator phase sequence
  • Serial annunciator module data link
  • Low coolant temperature
  • Low oil pressure
  • DC volts
  • Over / Under voltage (27/59)
  • Auto/start/stop control
  • Exciter diode monitor
  • Failure to start (overcrank)
  • 6 programmable digital inputs
  • Emergency stop
  • Generator mounted – rear facing
  • Programmable protective relaying functions:
  • Power factor (per phase & average)
  • Alarm acknowledge
  • DC volts
  • kVA (per phase, average & percent)
  • Overspeed

IVR includes:

  • RFI suppression
  • Emergency stop pushbutton
  • Package mounted radiator (except C175)
  • Overspeed
  • Emergency stop
  • kVAr (per phase, average & percent)
  • Environmental sealed front face
  • Customer data link (Modbus RTU)
  • Min / max exciter limiter
  • Speed adjust
  • Operating hours
  • True RMS AC metering, 3-phase, +/-2% accuracy
  • Reactive droop capability

Customizable screens

  • Volts (L-L & L-N)
  • PLC functionality
  • Digital indication for:
  • RPM
  • High coolant temperature
  • Digital indication for:
  • kW-hr (total)
  • Over / under frequency (81 o / u)
  • Low coolant temperature
  • 24 Volt DC operation
  • kW-hr (total)
  • Oil pressure (psi, kPa or bar)
  • Warning/shutdown with common LED indication of shutdowns for:
  • kVAr-hr (total)
  • EMCP 4.2B
  • 2 Programmable relay outputs (Form C)
  • kVAr-hr (total)
  • kW (per phase, average & percent)
  • kVAr (per phase, average & percent)
  • Engine cool-down timer
  • Over / Under frequency (81 o/u)
  • Engine cool-down timer
  • True RMS AC metering, 3-phase, +/-2% accuracy
  • Low coolant level
  • Frequency (Hz)
  • Controls:
  • Generator phase sequence
  • High coolant temperature

Communications:

  • Reverse Power (kW) (32)
  • Volts (L-L & L-N), frequency (Hz)
  • Alarm acknowledge
  • Environmental sealed front face
  • Controls:
  • Operating hours
  • Generator mounted – rear facing
  • Power Factor (per phase & average)
  • kW (per phase, average & percent)
  • Programmable protective relaying functions:
  • Engine cycle crank
  • Reverse Power (kW) (32)
  • 24-volt DC operation
  • Lamp test
  • Text alarm / event descriptions
  • Failure to start (overcrank)
  • Generator set packages include Caterpillar’ s Voltage Regulator (IVR)
  • Warning / shutdown with common LED indication of shutdowns for:
  • Text alarm / event descriptions
  • 4 programmable relay outputs (Form A)
  • Lamp test

Load histogram feature

  • Coolant temperature
  • Auto / start / stop control
  • Overcurrent (50 / 51)
  • kVA (per phase, average & percent)
  • KVAR/PF modes
  • Engine cycle crank
  • 3 Phase voltage sensing
  • 2 Programmable digital outputs
  • Low oil pressure
  • Reverse Reactive Power (kVAr) (32RV)
  • EMCP 4 Genset Controller
  • RPM
  • Oil pressure (psi, kPa or bar)
  • Amps (per phase & average)
  • Low coolant level
  • Amps (per phase & average)
  • EMCP4.2 controller including:

COOLING SYSTEM

  • Radiator fan and fan drive
  • Fan and belt guards
  • JWAC
  • Caterpillar Extended Life Coolant
  • Coolant level sensors
  • Coolant drain line with valve

EXHAUST SYSTEM

  • Dry Exhaust Manifold.
  • Exhaust flange outlet(s)

FUEL SYSTEM

  • Fuel cooler; not included with packages without radiator
  • Flexible fuel lines – shipped loose
  • Secondary fuel filters
  • Fuel priming pump

GENERATORS AND ATTACHMENTS

  • LV:
  • Winding temperature detectors
  • 3 phase brushless, salient pole
  • 1800 Frames are form wound, permanent magnet, with winding temperature detectors
  • NEMA Class H insulation, Class H temperature rise at 40C ambient (125C prime/150C standby)
  • Generator set packages include Caterpillar’s Digital Voltage Regulator (CDVR)
  • CDVR includes reactive droop capability, 3-phase voltage sensing, KVAR/PF modes, RFI suppression, min/max exciter. Limiter and exciter diode monitor
  • 6 lead
  • Internal Excitation
  • Busbar connections, top center mounted, top cable entry. 50 Hz models: IEC standard hole pattern
  • Random wound

GOVERNING SYSTEM

  • Woodward 2301A isochronous governor

LUBE SYSTEM

  • Integral lube oil cooler
  • Oil filter, filler and dipstick
  • Oil drain lines and valve
  • Fumes disposal
  • Gear type lube oil pump.
  • Lubricating oil.

MOUNTING SYSTEM

  • Rubber anti-vibration mounts (shipped loos
  • Rails – engine/generator/radiator mounting

STARTING / CHARGING SYSTEM

  • Battery disconnect switch
  • Battery and battery rack w/cables
  • 24-volt electric starting motor

GENERATOR AND ATTACHMENTS

  • Random wound
  • LV:
  • 6 lead
  • 3 phase brushless, salient pole

GENERAL

  • Right hand servicing
  • Caterpillar Yellow with high gloss black rails & radiator
  • Flywheel and Flywheel housing-SAE No. 00
  • SAE Standard Rotation
  • Paint – Caterpillar Yellow except rails and radiators gloss black

Caterpillar 3512 Genset 1250KW H202

Visit our other inventory

Overview

  • Category : Diesel
  • Item Number : H202
  • Offer Type : For Sale
  • Quantity : 1
  • Electrical Output : 1250 KW
  • Type of Equipment : Reciprocating
  • Manufacture : Caterpillar
  • Model : 3512
  • Application : Industrial
  • Rating : Standby
  • Fuel Type : Diesel (LFO)
  • Hours of Operation : 7611
  • Condition : Used
  • Alternator : Caterpillar
  • Frequency : 60 HZ
  • Voltage : 4160/2400 volts
  • Phase : 3
  • Mounted Type : Containerized Sound Attenuated
  • Enclosure Certification : CSC, ISO, CE
  • Fuel Tank : Yes
  • Operational on Inspection : Yes